This recipe is extremely adaptable to your taste. However, if you do wish to can it, do not alter the proportions of vinegar to other ingredients. You can alter spices interchangeably.
Recipe courtesy of Sean Timberlake
Maple-Bourbon Ketchup
Total:
13 hr 15 min
Active:
25 min
Yield:
About 8 cups
Level:
Intermediate
Total:
13 hr 15 min
Active:
25 min
Yield:
About 8 cups
Level:
Intermediate

Ingredients

  • 2 teaspoons black peppercorns
  • 7 to 8 cardamom pods
  • 1 teaspoon coriander seeds
  • 2 quarts tomato puree
  • 1 cup maple syrup
  • 1/4 cup bourbon
  • 2 teaspoons kosher salt
  • 1/2 cup cider vinegar
  • 2 teaspoons fish sauce 

Directions

Special equipment: Canner

Prepare the jars and lids: Wash all jars and lids thoroughly with soap and water and rinse well. Fill your canner with enough water to cover the jars by at least 1 inch and bring to a simmer. Using a pair of canning tongs, lower the jars in gently, tilting them to fill with the hot water. In a small saucepan, keep some water warm but not boiling; place the lids in the water. Have an additional kettle of water on to boil.

Make the ketchup: Wrap peppercorns, cardamom and coriander in cheesecloth or place in a tea infuser and add to tomatoes. Bring tomato puree, syrup, bourbon and salt to a boil. Reduce heat and simmer for about 30 minutes, stirring frequently to avoid scorching, until it darkens, thickens and is reduced by about a third. Add vinegar and fish sauce, and stir to combine. Remove the spice sachet, and remove sauce from heat.

Fill and close the jars: Using canning tongs, remove the jars from the canner, carefully pouring the water back into the canner. Set next to the ketchup in the saucepan. Turn the heat under the canner to high. Use a ladle to pour the ketchup into the jars through a canning funnel, leaving 1/2-inch headspace at the top. Run a clean chopstick around the inside of the jar to dislodge any trapped air. Wipe the rims of the jars with a damp paper towel. Place the lids on, and screw on the rings until just finger-tight.

Seal the jars: Using canning tongs, gently transfer the jars to the canner, taking care to keep them vertical. When all the jars are in the canner, there should be at least 1" water covering them; if you need more, add water from the kettle until the jars are sufficiently covered. Bring the water to a full rolling boil, and process for 10 minutes.

Remove and cool: Using canning tongs, gently remove the jars from the canner and transfer them to a kitchen towel or cooling rack, again keeping them vertical. Do not set hot jars directly on to cool counter surfaces. Leave to cool, undisturbed, for at least 12 hours. If any of the jars do not seal when cool, reprocess using the method above, or refrigerate and use immediately.

Label and store: Add a label to the lid or side of your jar, noting the date it was canned. Remove the rings and store jars in a cool, dark place for up to one year. Refrigerate after opening.

Properly handled sterilized equipment will keep canned foods in good condition for one year. Making sure hands, equipment and surfaces in your canning area are clean is the first step in canning. Tips: Jars should be made from glass and free of any chips or cracks. Preserving or canning jars are topped with glass, plastic or metal lids that have a rubberlike seal. Two-piece metal lids are most common. To prepare jars before filling: Wash jars with hot, soapy water, rinse them well and arrange them open-side up, without touching, on a tray. To sterilize jars, boil them in a large saucepan, covered with water, for 10 minutes. Jars have to be sterilized only if the food to be preserved will be processed for less than 10 minutes in a boiling-water bath or pressure canner. To sterilize jars, boil them in a large saucepan, covered with water, for 10 minutes. Follow manufacturer's instructions for cleaning and preparing lids and bands. Use tongs or jar lifters to remove hot sterilized jars from the boiling water. Be sure the tongs are sterilized too: Dip the tong ends in boiling water for a few minutes before using them. All items used in the process of making jams, jellies, preserves and pickles must be clean, including any towels and especially your hands. After the jars are prepared, you can preserve the food. It is important to follow any canning and processing instructions included in the recipe and refer to USDA guidelines about the sterilization of canned products. Find Information information on canning can be found at the National Center for Home Food Preservation website: http://nchfp.uga.edu/.

More from:

Kitchen Adventures

IDEAS YOU'LL LOVE

Doughnuts with Maple-Bourbon Glaze

Recipe courtesy of Hedy Goldsmith

Maple Bourbon Sweet Potato Pie

Recipe courtesy of Karen Barker

Cooking Tips

How to Poach Eggs Perfectly

Watch videos from Cooking Channel shows and chefs. Learn to prepare feature recipes and relive your favorite moments

On TV

So Much Pretty Food Here